Your cart is empty.
Your cart is empty.Product Description
This 160 PSI air shock controller allows driver controlled air shock pressure right from the driver's seat. The kit includes a universal connector for most air shocks including factory installed, a rugged on board air compressor, and a dash mount gauge panel, hardware, and air lines. The kit comes with complete instructions for easy installation and is back by a 2 year limited warranty.
Amazon.com
The Air Lift 25804 Air Shock Controller Kit provides an easy and effective way for drivers to monitor and maintain the air pressure in their air shocks with the push of a dashboard button. Operating without the need for an air tank or a connection to your car battery, the 25804 Air Shock Controller Kit consists of a dashboard mountable pressure gauge, a rugged but ultra compact air compressor and all the air line, mounting hardware and electrical connections needed for quick, easy do-it-yourself installation.
Dashboard air management specifically for air shocks
View larger.
Easy installation via an existing air shock T-fitting
View larger.
Perfect Push-Button Air Shock Pressurization
Air shocks are designed to be adjusted to ease your ride, as well as raise your vehicle chassis to a higher position when it is heavily loaded or requires additional ground clearance, but they are not always able to be conveniently adjusted. The Air Lift 25804 Air Shock Controller Kit changes that.
A compact air management system specifically designed to pressurize and depressurize your vehicle's already installed air shocks, right from the dashboard, the Air Lift 25804 Air Shock Controller Kit consists of a small, but durable air compressor that is connected at one end to a pressure gauge at the dashboard and at the other, to your air shocks (T-fitting not included). The compressor is powerful enough to pressurize your shocks without the need for an air tank and is conveniently powered via a connection to your vehicle's 15-amp minimum fuse box, usually located below the dashboard. Around the dashboard is also where the unit's single needle pressure gauge is best located, using the included self-tapping screws. In addition to registering pressures up to 200 psi,* this gauge also features an easy-to-use on/off switch and a one-touch deflate button to lower your vehicle just as easy as it is raised. The kit also contains all neccessary mounting hardware, a generous length of air line and instruction manual.
Features
- Allows driver control for air shock pressure right from the driver seat
- Includes rugged onboard air compressor
- Utilizes a universal connector suitable for most air shocks including those factory installed
- Option to control four air springs in pairs from one compressor
- Includes dash mount gauge panel, hardware and a generous length of air line
- Easy to install and powered via a connection to your vehicle's fuse box
Two Year Limited Warranty
Air Lift Company warrants its Air Lift 25804 Air Shock Controller Kit to the original retail purchaser against manufacturing defects for two (2) years when used on catalog-listed applications on cars, vans, light trucks and motor homes under normal operating conditions. The warranty does not apply to products that have been improperly applied, improperly installed, used in racing or off-road applications, used for commercial purposes, or which have not been maintained in accordance with installation instructions furnished with all products.
*Pressures in excess of 160 psi may result in premature compressor failure and/or air leaks in the air line connections.
Pedro
Reviewed in Mexico on February 27, 2025
Buen equipo
Jerry Mast
Reviewed in the United States on January 21, 2025
Goes good with the Airlift airbags
Customer
Reviewed in the United States on September 23, 2024
I bought this as a set for a 2017 Ram 1500. I was towing a heavy trailer and did not like the squat the truck had. The installation was very straightforward and I found some tips on you tube to make it even easier. It came with everything needed from mounting hardware to the length of hose. I ran it into my center console. Take your time with the install, don't rush it and you'll be very happy. The unit is very reliable. I'm in Florida with lots of rain, deep puddles, dust and dirt. I do not operate the pump unless I'm in a dry spot with clean air and I have had zero problems. I've had it installed for several months now and I couldn't be happier. If your in a very dusty area I would recommend putting a pre filter over the entire unit, the same ones used for a oiled cold air filter would work perfectly. The only thing I added that did not come with the kit was a wire protector sleeve. I used it to cover the air hose everywhere underneath the chassis. The hose is well built but I know there's going to be bumps and vibration so I used the sleeve to mitigate any friction damage. The squat was completely gone even with a max load. However... Keep in mind this will not take the place of a load leveler. The 1,000 lbs provided by these bags only helps the downward weight in the rear. Your front will still lift up. For heavy gear in the truck bed, or helping with squat from a regular load tow this is your answer. If your heavy hauling over longer distance I would say this is a nice compliment to a load leveling setup. The bags require a minimum pressure of 5 psi at all times. This locks them in place and keeps them from chaffing on the coil springs. This minimum 5 psi changed the ride feel of my truck when it's empty, the best way to describe it is that it went from feeling like a 1500 to a 2500 when going over bumps. Some of your cushy car-ride like experience in the 1500's will be gone, but you have the feel of a heavier duty truck. This particular kit read like it was actually intended for a air shock system, but it works perfectly fine for my two full size airbags. The pump doesn't run longer than 30 seconds to go from zero to max psi. Hope this helps!
chuck licari
Reviewed in the United States on September 20, 2024
Works as described and good quality
nanle
Reviewed in the United States on November 11, 2024
It provides excellent control over my air shocks, making my ride smoother and more comfortable. Installation was straightforward, and the system works perfectly.
2stroke
Reviewed in Canada on October 20, 2024
Easy to install, and fills rear bags fine. I did have an issue with 2 separate gauges out of the box. It says not to tamper but after taking off fitting from back of gauge, it appeared some sort of grease or lubricant was blocking off the small orifice hole for the air to travel to the gauge. Once cleaned it worked fine. I'm guessing assembly worker may have applied to much maybe when slipping on gauge assembly hose fittings. All good now
Cal
Reviewed in the United Kingdom on July 16, 2023
Very impressive bit of kit 100%
Patrick Spiteri.
Reviewed in Australia on March 1, 2023
Product is very good
B. Billy
Reviewed in the United States on March 21, 2022
I have airbag helper on the rear leaf springs on my 05 Dodge Ram, and I used to have to pump up the bags using a bicycle pump, and that was annoying and inconvenient to do. I got this, was a good price, and the install was very easy. I put the compressor in the bed of the truck, because it is loud when its on. The kit came with enough hose and wiring to put pretty much anywhere you want it. The gauge lights up if you want it to, you just have to wire that up, the air release button is right next to the on switch. My system seems to have a slow leak, because every morning, I have to air it back up, but that's not a huge issue, I'll just have to find that leak. It is so much more convenient to just press a button to air up my system now, its awesome. Plenty of power to air up the helper air bags that I use, I would recommend this to everyone.
Duffy971
Reviewed in Canada on March 30, 2020
Good compact compressor. I installed inside the cab under dash to run air suspension. Takes 30seconds to fill bags. They send you the new compressor and not the one in the photo. The wiring connectors were junk, I used heat shrink ones. The wiring diagram does not show the light in the gauge or a good way to wire it in.To sum up. Product is good for the price.
Getch
Reviewed in the United States on April 20, 2015
Bought it for my 08 F150 to help while towing my travel trailer. Simple straight forward installation with minimal tools and mechanical skills. I mounted the compressor on the inside of my frame rail because Air Lift says that's the best place so it can get cooler air rather than the engine compartment. I have found that since I bought it and placed it there (under the truck) that I really don't use it much to air up. That being said, I don't see why you couldn't mount it in the engine compartment, it would get enough air and would be better protected from the elements.Some issues I have had so far with this unit:1. The gauge setup could be a lot more modern lookingto blend in with the interior.2. Trying to hook the light up around the gauge bezel was a bit of a cluster...the instructions don't even cover that so your'e on your own there. Even though there's google it's still nice to have something on paper.3. Depending on where you mount it the wires and air line stick out and make look pretty messy because you're rather limited on where you can put it in a F150.4. This is my own fault, but the air line chaffed and wore a hole in the line on my way back from Texas. My quick fix was to cut the line and bypass the gauge. Keep extra unions handy and about 10 feet of hose with you when you travel.Now for the good points:1. It was designed for air shocks, but I use it for my air bags and it has no problem pushing air to them.2. There is plenty of air line and wire to run it pretty much any where.3. The instructions for the install are easy and it took me about an hour or so to install.4. The most important point of all is that it holds the air!! When you use the air line that comes with it. I used air line I bought from NAPA .97 cents a foot to patch the hole I had and it slowly leaks air. It fixed it, but I don't want to worry about watching every time I go on a road trip.So with all that being said I think its a great little setup. Could I have done it myself for less money? Yes, but I didn't feel like throwing together a system when I could have a few less headaches by just getting the whole kit. One last note, do yourself a favor and buy some wire loom (the plastic stuff that covers wires) and run your air lines and wires through it. Hope this little bit of info helps.
Recommended Products
